The Check List !

Component	donor	modification	why	component condition
Front suspension
uprights brake rotors calipers road springs shock absorbers all rubber bushings wheel bearings steering rack hydraulic brake lines	GT6 GT6 GT6 GT6 Spit new new ? ?? ?? ??	swap between cars swap between cars swap between cars swap between cars swap between cars new polyurethane install new install new swap between cars ?? ??	heavier duty larger dia. heavier duty stronger, softer adjustable KYB's (donor) tighten everything up for safety sake I have extras ??? Spit and 6 were different ratios! ???	nearly new nearly new nearly new nearly new nearly new nearly new nearly new nearly new nearly new ?? ??
Rear suspension
lower a-arms frame brackets rotoflex axles swing axles leaf spring shock mounts shock absorbers all rubber bushings wheel bearings hydraulic brake lines	N/A N/A N/A Spit Spit Spit Spit new new new ?? ??	N/A N/A N/A swap rear brakes clean and paint N/A Corvette air shocks new polyurethane install install install ??	N/A N/A N/A simpler maintenance proper weight swing spring stock configuration originally on donor - camber while it's all apart, why not! for safety sake	N/A N/A N/A nearly new nearly new N/A ?? new new new
Engine compartment
engine motor mounts oil cooler starter radiator radiator mounts choke cable throttle cable electrical wiring alternator exhaust carburation starter clearance painting	GT6 GT6 GT6 GT6 GT6 new new ? ?? Delco	swap between cars swap between cars ??? swap between cars swap between cars weld/bolt in mounts swap between cars swap between cars swap between cars swap between cars swap between cars swap between cars cut out tunnel --	obvious! always a good practice ??? equipment match equipment match equipment match equipment match equipment match equipment match higher output at idle Maniflow header equipment match clearance issue it needs it ...BAD!	recently rebuilt new ??? OK OK new new ?? new OK OK -- --
Driveline
transmission rear tranny mounts driveshaft rear differential tranny tunnel cover	GT6 GT6 GT6 GT6 Spit	nothing needed swap between cars swap between cars swap between cars none needed.	given given given 3.27 ratio to match 6 cyl. aftermarket solid fiberglass	recently rebuilt good good good good
Interior
seats seat belts carpet steering column w/ all controls	GT6 75 Spit new 78 Spit	re-upholster clean them up install new design harness to interface to new switch configurations	highback one piece buckets clasp on tunnel, no lead in color change - beige / light tan stalk levers and column lock/key position

©1987-2010 All material copyright© Teglerizer 1996-2008	last edited 3/15/08	hits since last reset

Spit6 / CGT6 Project